SAFETY DATA SHEET
Araldite 506
1. IDENTIFICATION
Product Identifiers
Product Name:
Araldite 506
Other Names:
Araldite 506
Product Number(s):
EMS10910
CAS Number:
N/A
Recommended use of the chemical and restriction on use
Laboratory use
Company Details
ProSciTech Pty Ltd
11 Carlton Street
KIRWAN QLD 4817
Australia(07) 4773 9444www.proscitech.com
11 Carlton Street
KIRWAN QLD 4817
Australia(07) 4773 9444www.proscitech.com
Emergency Contact Details
ProSciTech Pty Ltd
11 Carlton Street
KIRWAN QLD 4817
Australia(07) 4773 9444www.proscitech.com
11 Carlton Street
KIRWAN QLD 4817
Australia(07) 4773 9444www.proscitech.com
2. HAZARDS IDENTIFICATION
Classification of the substance or mixture
GHS08 Health hazard
GHS07
GHS07
Label Elements
Signal Words
Warning
Hazard Statement(s)
H341 Suspected of causing genetic defects
H351 Suspected of causing cancer
H315 Causes skin irritation
H319 Causes serious eye irritation
H317 May cause an allergic skin reaction
H335 May cause respiratory irritation
H227 Combustible liquid
H351 Suspected of causing cancer
H315 Causes skin irritation
H319 Causes serious eye irritation
H317 May cause an allergic skin reaction
H335 May cause respiratory irritation
H227 Combustible liquid
Precautionary Statement(s)
P202 Do not handle until all safety precautions have been read and understood.
P210 Keep away from heat, hot surface, sparks, open flames and other ignition sources. - No smoking.
P261 Avoid breathing dust/fume/gas/mist/vapours/spray.
P264 Wash thoroughly after handling.
P271 Use only outdoors or in a well-ventilated area.
P272 Contaminated work clothing should not be allowed out of the workplace.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
P302+P352 IF ON SKIN: wash with plenty of water.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do - continue rinsing.
P308+P313 IF exposed or concerned: Get medical advice/attention.
P361+P364 Take off immediately all contaminated clothing and wash it before reuse.
P333+P313 IF SKIN irritation or rash occurs: Get medical advice/attention.
P337+P313 IF eye irritation persists: Get medical advice/attention.
P370+P378 In case of fire: Use CO₂, powder or water to extinguish.
P403+P233 Store in a well-ventilated place. Keep container tightly closed.
P405 Store locked up.
P210 Keep away from heat, hot surface, sparks, open flames and other ignition sources. - No smoking.
P261 Avoid breathing dust/fume/gas/mist/vapours/spray.
P264 Wash thoroughly after handling.
P271 Use only outdoors or in a well-ventilated area.
P272 Contaminated work clothing should not be allowed out of the workplace.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
P302+P352 IF ON SKIN: wash with plenty of water.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do - continue rinsing.
P308+P313 IF exposed or concerned: Get medical advice/attention.
P361+P364 Take off immediately all contaminated clothing and wash it before reuse.
P333+P313 IF SKIN irritation or rash occurs: Get medical advice/attention.
P337+P313 IF eye irritation persists: Get medical advice/attention.
P370+P378 In case of fire: Use CO₂, powder or water to extinguish.
P403+P233 Store in a well-ventilated place. Keep container tightly closed.
P405 Store locked up.
Primary route(s) of entry
Irritant to skin and mucous membranes. Irritant to eyes
Human Health
Inhalation:
No further relevant information available.
Ingestion:
No further relevant information available.
Eyes:
Irritating effect.
Skin:
Irritant to skin and mucous membranes. Sensitization possible through skin contact.
Environment
Water hazard class 2 (Self-assessment): hazardous for water
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
Also poisonous for fish and plankton in water bodies.
Toxic for aquatic organisms
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
Also poisonous for fish and plankton in water bodies.
Toxic for aquatic organisms
3. COMPOSITION/INFORMATION ON INGREDIENTS
Name
CAS No.
Content (w/w)
Classification
bisphenol-A-(epichlorhydrin) epoxy resin
25068-38-6
>50-≤100%
Not Available
(BGE) butyl glycidyl ether
2426-08-6
>10-≤25%
Not Available
4. FIRST AID MEASURES
Ingestion
If symptoms persist, consult a doctor.
Inhalation
Supply fresh air and to be sure call for a doctor.
In case of unconsciousness place patient stably in side position for transportation
In case of unconsciousness place patient stably in side position for transportation
Skin Contact
Immediately wash with water and soap and rinse thoroughly
Eye Contact
Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
Other Information
No further relevant information available
5. FIREFIGHTING MEASURES
Suitable extinguishing equipment
CO₂, extinguishing powder or water spray. Fight larger fires with water spray or alcohol resistant foam
HAZCHEM
No further relevant information available.
Special protective equipment and precautions for fire fighters
6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Inform respective authorities in case of seepage into water course or sewage system.
Do not allow to enter sewers/ surface or ground water
Do not allow to enter sewers/ surface or ground water
Environmental precautions
Water hazard class 2 (Self-assessment): hazardous for water
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
Also poisonous for fish and plankton in water bodies.
Toxic for aquatic organisms
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
Also poisonous for fish and plankton in water bodies.
Toxic for aquatic organisms
Methods and materials for containment and clean up
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Dispose contaminated material as waste according to item 13.
Ensure adequate ventilation
Dispose contaminated material as waste according to item 13.
Ensure adequate ventilation
7. HANDLING AND STORAGE
Precautions for safe handling
Ensure good ventilation/exhaustion at the workplace.
Prevent formation of aerosols
Prevent formation of aerosols
Conditions for safe storage
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Standards
Material
TWA ppm
TWA mg/m3
STEL ppm
STEL mg/m3
2426-08-6 (BGE) butyl glycidyl ether
50ppm
270 mg/m³
-
Engineering controls
Keep away from foodstuffs, beverages and feed
Personal protective equipment
Eye and face protection
Tightly sealed goggles
Skin protection
Protective gloves - The glove material has to be impermeable and resistant to the product/ the substance/ the preparation
Body protection
Avoid contact with the eyes and skin
Respiratory protection
In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer exposure use respiratory protective device that is independent of circulating air
9. PHYSICAL AND CHEMICAL PROPERTIES
General information
Appearance
Colourless liquid
Odour
Characteristic
pH
Not determined
Vapour Pressure
Undetermined
Density
Undetermined
Boiling Point
Undetermined
Melting Point
Undetermined
Solubility
Not miscible or difficult to mix
Specific Gravity of Density
Undetermined
Flash Point
78 °C (172.4 °F)
Flammable (Explosive) Limits
Not flammable
Ignition Temperature
215 °C (419 °F) - Product is not selfigniting
Formula
N/A
10. STABILITY AND REACTIVITY
Reactivity
No further relevant information available
Chemical stability
Stable under normal circumstances
Possibility of hazardous reactions
No dangerous reactions known
Conditions to avoid
No further relevant information available
Incompatible materials
No further relevant information available
11. TOXICOLOGICAL INFORMATION
Acute effects
2426-08-6 (BGE) butyl glycidyl ether
Oral LD50 2,050 mg/kg (rat)
Dermal LD50 788 mg/kg (rabbit)
Oral LD50 2,050 mg/kg (rat)
Dermal LD50 788 mg/kg (rabbit)
Eye contact
Irritating effect
Skin contact
Irritant to skin and mucous membranes
Ingestion
No further relevant information available
Inhalation
No further relevant information available
Toxicity and irritation
Harmful
Irritant
Irritant
12. ECOLOGICAL INFORMATION
Ecotoxicity
2426-08-6 (BGE) butyl glycidyl ether
EC50 mg/kg (rat)
EC50 mg/kg (rat)
Persistence and degradability
No further relevant information available
Bioaccumulative potential
No further relevant information available
Other adverse effects
Water hazard class 2 (Self-assessment): hazardous for water
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
Also poisonous for fish and plankton in water bodies.
Toxic for aquatic organisms
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
Also poisonous for fish and plankton in water bodies.
Toxic for aquatic organisms
13. DISPOSAL CONSIDERATIONS
General information
Must not be disposed of together with household garbage. Do not allow product to reach sewage system.
Disposal must be made according to official regulations
Disposal must be made according to official regulations
14. TRANSPORT INFORMATION
ADG label required
HAZCHEM
No further relevant information available.
UN Number
UN3082
Proper shipping name
ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID,
N.O.S. (reaction product: bisphenol-A-(epichlorhydrin) epoxy
resin (number average molecular weight ≤ 700))
N.O.S. (reaction product: bisphenol-A-(epichlorhydrin) epoxy
resin (number average molecular weight ≤ 700))
Transport hazard class
9 Miscellaneous dangerous substances and articles
Packing group
III
Environmental hazard
Symbol (fish and tree)
Special precautions for users
Warning: Miscellaneous dangerous substances and articles
Additional information
Hazard identification number (Kemler code): 90
· EMS Number: F-A,S-F
· Stowage Category A
Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30 mL
Maximum net quantity per outer packaging: 1000 mL
Limited quantities (LQ) 5L
· Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30 mL
Maximum net quantity per outer packaging: 1000 mL
· EMS Number: F-A,S-F
· Stowage Category A
Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30 mL
Maximum net quantity per outer packaging: 1000 mL
Limited quantities (LQ) 5L
· Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30 mL
Maximum net quantity per outer packaging: 1000 mL
15. REGULATORY INFORMATION
Poisons Schedule Number
None of the ingredients is listed
Other Information
No further relevant information available
16. OTHER INFORMATION
SDS preparation date
13 February 2023
Comments
This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. This Safety Data Sheet (SDS) has been prepared in compliance with the Preparation of Safety Data Sheets for Hazardous Chemicals Code of Practice February 2016. It is the user's responsibility to determine the suitability of this information for adoption of necessary safety precautions. The information published in this SDS has been compiled from the publications listed in Section 16: to the best of our ability and knowledge these publications are considered accurate. We reserve the right to revise Safety Data Sheets as new information becomes available. Copies may be made for non-profit use.
This Safety Data Sheet (SDS) has been prepared in compliance with the Preparation of Safety Data Sheets for Hazardous Chemicals Code of Practice February 2016. It is the user's responsibility to determine the suitability of this information for adoption of necessary safety precautions. The information published in this SDS has been compiled from the publications listed in Section 16: to the best of our ability and knowledge these publications are considered accurate. We reserve the right to revise Safety Data Sheets as new information becomes available. Copies may be made for non-profit use.